Mitsubishi Mighty Max

The contact owns a 1991 Mitsubishi Mighty Max. The contact stated while the vehicle was parked, the driver's side front seat belt was latched; however, the front driver's seat belt buckle failed to latch as intended. The contact received notification of NHTSA Campaign Number: 95V103004 (Seat Belts). The vehicle was taken to the dealer for the recall repair; however, the contact was informed that the recall repair was completed. The failure reoccurred. The dealer was made aware of the failure.…

TL* THE CONTACT OWNS A 1992 MITSUBISHI MIGHTY MAX EQUIPPED WITH NEPTUNE UN101 (NA) TIRES, SIZE: 195/75/R14 (NA). WHILE DRIVING VARIOUS SPEEDS, THE CONTACT LOST CONTROL OF THE VEHICLE. THE CONTACT PULLED THE VEHICLE OVER AND NOTICED THAT THE TIRE BELT HAD SHIFTED ON THE TIRES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VIN WAS UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 83,500 AND THE TIRE…

TIRE TREADS ARE SEPARATING/CRACKING IN BETWEEN THE TREADS. NOT A FAILURE YET, BUT I DON'T THINK THIS IS NORMAL OR SAFE, AND JUST WANT IT TO BE KNOWN IN CASE OTHERS ARE HAVING THE SAME PROBLEM. *TR

WHILE DRIVING ENGINE SHUT DOWN. CONSUMER GOT THE VEHICLE TO COAST OFF THE RAMP. CONSUMER NOTICED SMOKE COMING FROM THE ENGINE, AND ENGINE WAS DRIPPING GAS. FUEL INJECTOR WOULD NOT CUT OFF, WHICH FLOODED THE ENGINE. *AK THE REPAIR SHOP FOUND THAT THE MAIN CONTROL MODULE FAILED WHICH CAUSED ABOUT 1 GALLON OF GAS TO BE SPILLED INTO THE ENGINE OIL. THERE WAS GAS ALL OVER THE ENGINE AND A LARGE POLL OF GAS UNDER THE CAR. *NM

CONSUMER WAS DRIVING ON THE FREEWAY AT APPROXIMATELY 55 MPH, AND WHEN TURNING, VEHICLE WENT ONTO THE SHOULDER. THEN, CONSUMER PUT IT BACK ON THE ROAD. CONSUMER LOST CONTROL OF VEHICLE, AND IT WENT ONTO THE OTHER SIDE, AND INTO AN EMBANKMENT, CAUSING THE VEHICLE TO FLIP OVER ON ITS ROOF. TWO FRONT TIRES CAME COMPLETELY OFF THE RIM. *AK

WHILE DRIVING 30 MPH, THE CONSUMER DEPRESSED THE PEDAL AND IT TRAVELED TO FLOOR. THE CONSUMER DOWN SHIFTED FOR THE VEHICLE TO COME TO A STOP. THE CONSUMER INSPECTED THE VEHICLE, AND NOTICED THAT THE BRAKE LINE HAD RUSTED, CAUSING BRAKE FLUID TO LEAK. *AK THE ABS HAD RUSTED IN THE AREA WHERE THE LINES RAN BETWEEN THE FRAME OF THE VEHICLE AND THE EXHAUST PIPE/MUFFLER. *SC *JB

THE ENGINE WOULD SHUT DOWN WITH NO PRIOR WARNING, THE COIL ASSEMBLY WAS REPLACED (35000) AND LAST MONTH IT FAILED AGAIN, AFTER THE VEHICLE HAD BEEN AT THE DEALER FOR 3 DAYS THEY DETERMINED THAT THE ELECTRICAL SYSTEM WAS NOT WORKING PROPERLY. NLM

THIS PART HAS BROKEN PROBABLY MORE THAN SIX TIMES. THE FIRST COUPLE OF TIMES, THE TRUCK WAS TOWED TO A MECHANIC RATHER THAN THE DEALER, THINKING THAT THIS WAS JUST A SMALL PROBLEM. AFTER TWO VISITS TO THE SAME MECHANIC, THE TRUCK WAS THEN TOWED TO THE DEALER. THE FIRST TIME AT THE DEALER (DOBBS BROS. MITSUBISHI-MEMPHIS), I WAS TOLD THAT THE BALANCE SHAFT WAS OUT OF BALANCE. $715.78 LATER (THIS PART IS NOW UNDER A ONE YEAR/12,000 MILE WARRANTY), THE SHAFT FORK BREAKS AGAIN. THIS TIME, I WAS TOLD…

SHAFT AND FORK PIECE BROKE IN HALF. THIS HAS OCCURED 3 TIMES, 1998,1999 AND CURRENT. ONCE WITH THE ORIGINAL PART AND TWICE WITH THE REPLACEMENT PARTS. IT IS A HAZARD WHEN DRIVING IN MOTION. YOU'RE JOLTED WITH TREMENDOUS FORCE WHEN IT BREAKS WITHOUT NOTICE AND SUDDEN LOSS OF SPEED. MAY CAUSE CAR FOLLOWING IN REAR TO BACK END VEHICLE AND CREATE AN ACCIDENT.*AK

CLUTCH WILL EASILY BREAK. IN NOVEMBER OF 1999 CLUTCH BROKE , AND IN APRIL 2001 CLUTCH BROKE AGAIN. DEALER WAS NO LONGER WILLING TO REPAIR CLUTCH. *AK